Back to Book

The Psychology of Management by Lillian Moller Gilbreth

3. "to impart knowledge or practical skill to;" "to guide in

1487 words  |  Chapter 202

learning, educate." "Educate," we find meaning "to instruct, to teach methodically, to prescribe to; to indoctrinate;" and by "indoctrinate" is meant "to cause to hold as a doctrine or belief." "To educate," says the same authority, "is to develop mentally or morally by instruction; to qualify by instruction and training for the business and duty of life." UNDER TRADITIONAL MANAGEMENT NO DEFINITE PLAN OF TEACHING.-- Under Traditional Management there is either no definite scheme of teaching by the management itself, or practically none; at least, this is usually the condition under the most elementary types of Traditional Management. In the very highest examples of the traditional plan the learner may be shown how, but this showing is not usually done in a systematic way, and under so-called Traditional Management is seldom in the form of written instructions. NO SPECIFIED TIME FOR OR SOURCE OF THE TEACHING.--Under Traditional Management there is no particular time in which this teaching goes on, no particular time allowed for the worker to ask for the instruction, nor is there any particular source from which he obtains the instructions. There is, moreover, almost every hindrance against his getting any more instruction than he absolutely must have in order to get the work done. The persons to whom he can possibly appeal for further information might discharge him for not already knowing. These persons are, if he is an apprentice, an older worker; if he is a journeyman, the worker next to him, or the foreman, or someone over him. An important fact bearing on this subject is that it is not to the pecuniary advantage of any particular person to give this teaching. In the first place, if the man be a fellow-worker, he will want to do his own work without interruption, he will not want to take the time off; moreover, he regards his particular skill as more or less of a trade secret, and desires to educate no more people than necessary, to be as clever as he is. In the third place, there is no possible reward for giving this instruction. Of course, the worker necessarily improves under any sort of teaching, and if he has a receptive mind, or an inventive mind, he must progress constantly, either by teaching himself or by the instruction, no matter how haphazard. GREAT VARIATION UNDER TRADITIONAL MANAGEMENT.--Only discussion of teaching under this type of management with many men who have learned under it, can sufficiently emphasize the variations to be found. But the consensus of opinion would seem to prove that an apprentice of only a generation ago was too often hazed, was discouraged from appealing for assistance or advice to the workers near him, or to his foreman; was unable to find valuable literature for home-study on the subject of his trade. The experience of many an apprentice was, doubtless, different from this, but surely the mental attitude of the journeymen who were the only teachers must have tended toward some such resulting attitude of doubt or hesitancy in the apprentice. MENTAL ATTITUDE OF THE WORKER-TEACHER.--Under the old plan of management, the apprentice must appear to the journeyman more or less of a supplanter. From the employee's standpoint it was most desirable that the number of apprentices be kept down, as an oversupply of labor almost invariably resulted in a lowering of wages. The quicker and better the apprentice was taught, the sooner he became an active competitor. There seldom existed under this type of management many staff positions to which the workers could hope to be promoted, certainly none where they could utilize to the fullest extent their teaching ability. There was thus every reason for a journeyman to regard the teaching of apprentices as unremunerative, irksome, and annoying. WORKER NOT TO BLAME FOR THIS.--The worker is not to be blamed for this attitude. The conditions under which he worked made it almost inevitable. Not only could he gain little or nothing by being a successful teacher, but also the bullying instinct was appealed to constantly, and the desire of the upper classmen in hazing days to make the next class "pay up" for the hazing that they were obliged to endure in their Freshman year. ATTITUDE OF THE LEARNER.--The attitude of the typical learner must frequently be one of hesitancy and self-distrust if not of fear, though conditions were so varied as almost to defy classification. One type of apprentice was expected to learn merely by observation and imitation. Another was practically the chore boy of the worker who was assigned to teach him. A third was under no direct supervision at all, but was expected to "keep busy," finding his work by himself. A fourth was put through a severe and valuable training by a martinet teacher,--and so on. TEACHING OFTEN PAINSTAKING.--It is greatly to the credit of the worker under this type of management that he was, in spite of all drawbacks, occasionally a painstaking teacher, to the best of his lights. He insisted on application, and especially on quality of work. He unselfishly gave of his own time and skill to help the apprentice under him. METHODS OF TEACHING USUALLY WRONG.--Unfortunately, through no fault of the worker-teacher the teaching was usually done according to wrong methods. Quality of resulting output was so emphasized that neither speed nor correct motions were given proper consideration. TEACHER NOT TRAINED TO TEACH.--The reason for this was that the worker had no training to be a teacher. In the first place, he had no adequate idea of his own capabilities, and of which parts of his own method were fit to be taught. In the second place, he did not know that right motions must be insisted on first, speed next, and quality of output third; or in other words that if the motions were precise enough, the quality would be first. In the fourth place he had no pedagogical training. LACK OF STANDARDS AN UNDERLYING LACK.--All shortcoming in the old time teaching may be traced to lack of standards. The worker had never been measured, hence had no idea of his efficiency, or of possible efficiency. No standard methods made plain the manner in which the work should be done. Moreover, no standard division and assignment of work allowed of placing apprentices at such parts of the work that quality could be given third place. No standard requirements had determined his fitness as a teacher, nor the specialty that he should teach, and no incentive held his interest to the teaching. These standards the worker-teacher could not provide for himself, and the wonder is that the teaching was of such a high character as it was. VERY LITTLE TEACHING OF ADULTS.--Under Traditional Management, teaching of adults was slight,--there being little incentive either to teacher or to learner, and it being always difficult for an adult to change his method.[1] Moreover, it would be difficult for a worker using one method to persuade one using another that his was the better, there being no standard. Even if the user of the better did persuade the other to follow his method, the final result might be the loss of some valuable elements of the poorer method that did not appear in the better. FAILURE TO APPRECIATE THE IMPORTANCE OF TEACHING.--An underestimation of the importance of teaching lay at the root of the lack of progress. This is so directly connected with all the other lacks of Traditional Management,--provision for adequate promotion and pay, standards, and the other underlying principles of Scientific Management, especially the appreciation of coöperation,--that it is almost impossible to disentangle the reasons for it. Nor would it be profitable to attempt to do so here. In considering teaching under Scientific Management we shall show the influence of the appreciation of teaching,--and may deduce the lacks from its non-appreciation, from that discussion. UNDER TRANSITORY SYSTEM TEACHING BECOMES MORE IMPORTANT.--Under Transitory Management the importance of teaching becomes at once more apparent. This, both by providing for the teaching of foremen and journeymen as well as apprentices, and by the providing of written systems of instructions as to best practice. The worker has access to all the sources of information of Traditional Management, and has, besides these, in effect, unsystematically derived standards to direct him. SYSTEMS MAKE INSTRUCTION ALWAYS AVAILABLE.--The use of written systems enables every worker to receive instruction at any time, to feel free to ask it, and to follow it without feeling in any way humiliated. The result of the teaching of these systems is a decided improvement in methods. If the written systems are used exclusively as a source of teaching, except for the indefinite teachers of the Traditional Management, the improvement becomes definitely proportioned to the time which the man spends upon the studying and to the amount of receptive power which he naturally has. INCENTIVES TO CONFORM TO SYSTEM.--The worker has incentives to follow the systems--
Previous Chapter Chapter List Next Chapter

Chapters

1. Chapter 1 2. CHAPTER I PAGE 3. CHAPTER II 4. CHAPTER III 5. CHAPTER IV 6. CHAPTER V 7. CHAPTER VI 8. CHAPTER VII 9. CHAPTER VIII 10. CHAPTER IX 11. CHAPTER X 12. CHAPTER I 13. 1. Management is a life study of every man who works with other 14. 2. A knowledge of the underlying laws of management is the most 15. 3. This knowledge is to be had _now_. The men who have it are 16. 4. The psychology of, that is, the mind's place in management is 17. 5. It is a division well fitted to occupy the attention of the 18. introduction to psychology and to management, can suggest the 19. 2. what we have defined as the "Transitory" plan of 20. 3. management which not only is not striving to be 21. 4. the distinctive name is the Taylor Plan of Management. 22. 1. To enumerate the underlying principles on which scientific 23. 2. To show in how far the other two types of management vary 24. 3. To discuss the psychological aspect of each principle. 25. 1. The relation of Scientific Management to the other types 26. 3. The relation between the various elements of Scientific 27. 4. The psychology of management in general, and of the three 28. 9. Welfare. 29. 2. Appearance and importance of the idea in Traditional and 30. 3. Appearance and importance of the idea in Scientific 31. 4. Elements of Scientific Management which show the effects 32. 5. Results of the idea upon work and workers. 33. 3. Contrary to a widespread belief that Scientific Management 34. 4. Scientific Management fosters individuality by 35. 5. Measurement, in Scientific Management, is of ultimate 36. 6. These measured ultimate units are combined into methods of 37. 7. Standardization under Scientific Management applies to all 38. 8. The accurate records of Scientific Management make 39. 9. Through the teaching of Scientific Management the 40. 10. The method of teaching of Scientific Management is a 41. 11. Incentives under Scientific Management not only stimulate 42. 12. It is for the ultimate as well as immediate welfare of 43. 13. Scientific Management is applicable to all fields of 44. 14. Scientific Management is applicable to self-management as 45. 15. It teaches men to coöperate with the management as well 46. 17. The psychological element of Scientific Management is the 47. 18. Because Scientific Management is psychologically right it 48. 19. This psychological study of Scientific Management 49. 20. Scientific Management simultaneously 50. 2. Halbert P. Gillette, Paper No. 1, American Society of 51. 6. F.W. Taylor, _Shop Management_, para. 16, Am. Soc. M.E., Paper 52. 9. Morris Llewellyn Cooke, _Bulletin No. 5 of the Carnegie 53. 10. F.W. Taylor, _Shop Management_, para. 234, Am. Soc. M.E., Paper 54. 13. Henry R. Towne, Introduction to _Shop Management_. (Harper & 55. 14. F.W. Taylor, _Principles of Scientific Management_, p. 123. 56. 16. F.W. Taylor, _Principles of Scientific Management_, p. 137. 57. CHAPTER II 58. 1. The importance of the study of the individual, and the 59. 2. The difficulty of the study, and the necessity for great 60. 3. The necessity of considering any one individual trait as 61. 4. The importance of the individual as distinct from the 62. 1. The work is more specialized, hence requires more 63. 2. With standardized methods comes a knowledge to the 64. 3. Motion study, in its investigation of the worker, supplies 65. 1. By psychological and physiological study of workers under 66. 2. By scientific study of the worker made before he comes 67. 1. Determining the capabilities of the boy, that is, seeing 68. 2. Determining the possibilities of his securing work in the 69. 11. Rewards must be prompt and provided for all 70. 12. Appreciation must be shown.[11] 71. 2. It is prepared for the particular individual who is 72. 1. When, where, how, and how much is individuality 73. 2. What consideration is given to the relation of the mind to 74. 3. What is the relative emphasis on consideration of 75. 6. What is the effect toward causing or bringing about 76. 9. L.B. Blan, _A Special Study of the Incidence of Retardation_, 77. 11. F.B. Gilbreth, _Cost Reducing System_, Chap. III. 78. CHAPTER III 79. 4. What are the results to the worker? 80. 9. Good health. 81. 1. That the position will be best filled by a very high and 82. 2. That the man is forced to use every atom of all of his 83. 3. That in many cases the work assigned for him to do calls 84. 4. That psychology tells us that a man fitted to perform some 85. 11. poor investigation of workers' special capabilities. 86. 4. assigning competent workers to fitting work. 87. 8. quantity of additional pay that shall be given for doing it. 88. 1. coöperation with the management in obtaining the prescribed 89. 2. the exercise of their ingenuity in making improvements 90. 3. the fitting of themselves for higher pay and promotion. 91. 4. Disciplinarian 92. 8. Inspector 93. 2. a good observer, able to note minute variations of method, 94. 3. a good teacher. 95. 1. the particular place in the field of knowledge in which 96. 2. the change in the type of criticism expected from the 97. 3. the far greater emphasis placed on duties as a teacher. 98. 6. an offense against the system (disobeying orders), falling 99. 1. in doing the work itself, as will be shown at length in 100. 2. outside of the regular working hours, but in connection 101. 2. Decide whether the place can be best handled as one, or 102. 2. the long time job. 103. 5. Gillette and Dana, _Cost Keeping and Management Engineering_, 104. 7. F.W. Taylor, _Shop Management_, para. 221-231. Harper Ed., 105. 12. For excellent example of special routing see: Charles Day, 106. 13. C. Babbage, _Economy of Manufacturers_. p. 172. "The constant 107. 14. F.W. Taylor, _On the Art of Cutting Metals_, Paper No. 1119, 108. 15. C.G. Barth, _Slide Rules for Machine Shops and Taylor System_. 109. 17. Adam Smith, _Wealth of Nations_, p. 2. "The greatest improvement 110. 18. H.K. Hathaway, _The Value of "Non-Producers" in Manufacturing 111. 19. Gillette and Dana, _Cost Keeping and Management Engineering_, 112. 20. Morris Llewellyn Cooke, _Bulletin No. 5, Carnegie Foundation for 113. 21. H.L. Gantt, _Work, Wages and Profits_, p. 120. 114. CHAPTER IV 115. 1. The student will discover, in the books on experimental 116. 2. He will receive priceless instruction in methods of 117. 4. What accurate measurement determines his 118. 3. time for overcoming delays. 119. 3. be willing to coöperate. 120. 2. that all get an ample compensation for what 121. 3. that under them general welfare is considered; 122. 2. the length of time required for a worker to do a 123. 3. the amount of rest and the time of rest required to 124. 3. how best to use them. 125. 4. furnish resulting timed elements to the synthesizer 126. 1. The maintained tension on a belt bears a close relation to 127. 2. The speed of a buzz planer determines its liability to 128. 2. what function it will be best to assign them to and to 129. 2. ability to assign men to the work which they should do, to 130. 3. ability to predict. On this ability to predict rests the 131. 2. The worker's judgment is appealed to. The method that he uses 132. 3. The worker's reasoning powers are developed. Continuous 133. 4. The worker fits his task, therefore there is no need of 134. 5. There is elimination of soldiering, both natural and 135. 1. The worker will become more and more willing to impart his 136. 2. G.M. Stratton, _Experimental Psychology and Its Bearing upon 137. 4. For apparatus for psychological experiment see Stratton, p. 38, 138. 6. Morris Llewellyn Cooke, Bulletin No. 5, _The Carnegie Foundation 139. 12. F.W. Taylor, _Shop Management_, pp. 398-391. Harper Ed., p. 179. 140. 13. President's Annual Address, Dec., 1906. Vol. 28, Transactions 141. 15. R.T. Dana, For Construction Service Co., _Handbook of Steam 142. 20. F.W. Taylor, _Shop Management_, para. 46. Harper Ed., p. 30. 143. CHAPTER V 144. 3. how many elements that it contains are likely to be 145. 4. how many new elements that it contains are likely to be 146. 5. the probable cost of the work after it has been studied-- 147. 6. The loss, if any, from delaying the work until after it 148. 7. the availability of trained observers and measurers, 149. 8. the available money for carrying on the investigations. 150. 2. "labor imposed, especially a definite quantity or amount 151. 3. "a lesson to be learned; a portion of study imposed by a 152. 5. "burdensome employment; toil." 153. 1. The tools and surrounding conditions with which the work 154. 3. The time that the work shall take is scientifically 155. 5. The quality of the output is prescribed. 156. 1. law of no ratio between the foot-pounds of work done and 157. 3. law of classification of work according to percentage of 158. 6. laws that will predict the right speed, feed and cut on 159. 7. laws for predicting maximum quantity of output that a man 160. 8. laws for determining the selection of the men best suited 161. 1. Compare _Mechanical Analysis_. Taylor and Thompson, _Concrete, 162. 9. London, _Engineering_, Sept. 15, 1911. 163. CHAPTER VI 164. 1. to analyze the best practice known into the smallest 165. 4. to synthesize the necessary standard elements into 166. 1. that all management data would be available to 167. 2. that such data, being available also to all standardizers, 168. 4. that, from a study and comparison of the collected data a 169. 8. All of these various savings could be invested in more 170. 9. These more valuable results would again be available to 171. 1. for use as records of successful methods which may be 172. 2. for use by the instruction card clerk in explaining to 173. 3. What to Do. 174. 2. Qualities of Products. 175. 3. Clearing up. This is the only type used by Scientific 176. 1. Because they directly increase output by eliminating 177. 2. Because all surroundings suggest an easy achievement. Knowing 178. 1. It gives the worker immediate knowledge of the prescribed 179. 2. He does not have to worry as to the maximum variation that 180. 3. There is no fear of criticism or discharge for using his 181. 2. The idea of perfection is not involved in the standard of 182. 6. For desirability of standard signals see R.T. Dana, _Handbook of 183. 8. F.W. Taylor, _Shop Management,_ para. 285, Harper Ed., 184. 14. Charles Babbage, _On the Economy of Machinery and Manufactures_, 185. 16. F.A. Parkhurst, _Applied Methods of Scientific Management, 186. 17. H.L. Gantt, paper 928, A.S.M.E., para. 15. 187. CHAPTER VII 188. 3. Increase efficiency. 189. 1. The necessity of having more accurate records of the 190. 2. The necessity for so training the worker, before, as well 191. 2. the work as it is planned out by the managers, and handed 192. 2. to route the worker to the placed materials. 193. 4. Conscious record, conscious programme. 194. 10. Standardized record, standardized programme. 195. 1. One of a gang, unconscious 196. 2. Individual output,--standardized 197. 1. Gillette and Dana, _Cost Keeping and Management Engineering_, 198. 3. Gillette and Dana, _Cost Keeping and Management Engineering_, 199. 5. William James, _Psychology, Briefer Course_, p. 179. 200. CHAPTER VIII 201. 1. "to point out, direct, show;" "to tell, inform, instruct, 202. 3. "to impart knowledge or practical skill to;" "to guide in 203. 1. In that he is required to render reasons in writing for 204. 2. That, as soon as work is placed on the bonus basis, the 205. 2. Teaching of right habits of doing the right methods. 206. 2. Worker has no opportunity under the old industrial 207. 5. Right habits can be instilled. 208. 5. The Management. } 209. 1. Written, by means of 210. 3. Object-lessons: 211. 4. The instruction comes at the exact time that the learner 212. 3. from actual practice in teaching. 213. 10. develops the will. 214. 2. read to oneself aloud--eyes and ears appealed to, also 215. 4. read aloud to one and also read silently by one,-- 216. 5. read aloud, and at the same time copied--eyes, ears, 217. 7. read to one while process is performed by oneself 218. 1. right motions first, that is to say,--the right number 219. 2. speed of motions second, that is to say, constantly 220. 3. constantly improving quality.[25] 221. 2. "The particular one of having images which are not 222. 4. mixed. 223. 3. that he may be sure of advancement with age and 224. 4. that he is sure of the "square deal." 225. 3. Competition with the standard record. 226. 1. During working hours, where the recognition of his 227. 2. Outside the work. He has, under Scientific Management, more 228. 1. A collection of knowledge relating in its entirety to the 229. 2. A definite procedure, that will enable the learner to 230. 12. Opportunities and demands for "thinking" 231. 16. Resultant happiness of worker. 232. 2. H.K. Hathaway, _Prerequisites to the Introduction of Scientific 233. 6. F.W. Taylor, _Shop Management_, para. 289, Harper Ed., 234. 8. W.D. Ennis, _An Experiment in Motion Study, Industrial 235. 9. C.S. Myers, M.D., _An Introduction to Experimental Psychology_, 236. 12. F.B. Gilbreth, _Bricklaying System_, chap. I, _Training of 237. 19. Imbert, _Etudes experimentales de travail professionnel ouvrier, 238. 21. _Ibid._, p. 138. William James, Psychology, Advanced Course. 239. 24. Prof. Bain, quoted In William James' _Psychology, Briefer 240. 30. Attracting the attention is largely a matter of appealing to 241. 39. M.S. Read, _An Introductory Psychology_, pp. 212-213. William 242. 51. For example, see W.D. Scott's _Increasing Efficiency in 243. 52. R.A. Bray, _Boy Labor and Apprenticeship_, chap. II, especially 244. 53. Wilfred Lewis, _Proceedings of the Congress of Technology_, 245. 56. For value of personality see J.W. Jenks's, _Governmental Action 246. 58. Compare with the old darkey, who took her sons from a Northern 247. 61. Morris Llewellyn Cooke, _Bulletin No. 5_ of _The Carnegie 248. 62. A well known athlete started throwing a ball at his son in 249. 63. Meyer Bloomfield, _The Vocational Guidance of Youth_, Houghton 250. 64. A. Pimloche, _Pestalozzi and the Foundation of the Modern 251. 65. Friedrich Froebel, _Education of Man_, "To secure for this 252. CHAPTER IX 253. 1. fines, which are usually simply a cutting down of wages, 254. 3. assignment to less pleasant or less desirable work. 255. 8. Professional standing. 256. 9. coöperative work 257. 3. industrial coöperation. These are defined and discussed at 258. 5. F.W. Taylor, _Shop Management_, para. 310-311, Harper Ed., 259. 6. See also C.U. Carpenter, _Profit Making in Shop and Factory 260. CHAPTER X 261. 3. physical development. 262. 2. Habits, under Scientific Management, 263. 3. Physical development 264. 1. As for habits we must consider 265. 2. General mental development is provided for by the experience 266. 1. Personal responsibility is developed by 267. 2. Responsibility for others is provided for by the 268. 3. Appreciation of standing is fostered by 269. 4. Self-control is developed by 270. 5. "Squareness." This squareness is exemplified first of all by 271. 1. Contentment is the outgrowth of the personal responsibility, 272. 2. The idea of brotherhood is fostered particularly through the 273. 3. The "will to do" is so fostered by Scientific Management that 274. 1. It will educate the worker to the point where workers will 275. 2. It will aid the cause of Industrial Peace. 276. 6. See remarkable work of Dr. A. Imbert, _Evaluation de la Capacite 277. 7. Clark and Wyatt, Macmillan, pp. 269-270. 278. introduction of new, 137.

Reading Tips

Use arrow keys to navigate

Press 'N' for next chapter

Press 'P' for previous chapter